Effect Of Quarry Dust On compressive Strength concrete

Effect Of Quarry Dust On compressive Strength concrete

Influence of Quarry Dust on Compressive Strength of

2016-6-7 · Objectives: In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20%, 30%, 40%, 50% replacement.Methods/Analysis: The fine aggregate is being replaced with fine aggregate and the compressive strength is determined for the concrete by testing the sample cube. The properties such as the specific gravity, fineness modulus, moisture content etc. are ...

IMPACT OF QUARRY DUST & DOLOMITE POWDER ON

2018-6-20 · ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · (2003) reported significant increase in compressive strength, modulus of rupture and split tensile strength when 40 percent of sand is replaced by Quarry Rock Dust in concrete. Nagaraj (2000) studied that the consumption of cement content, workability, compressive strength and cost of concrete made with Quarry Rock Dust.

Effect of quarry rock dust on the flexural strength of ...

2018-6-1 · The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarry-sand concrete based on its compressive strength. 3.

(PDF) Effect of quarry rock dust on the flexural strength ...

2017-12-1 · The effect of quarry dust on the flexural strength of concrete has been experimentally studied and reported in this paper. Concrete used was prepared by replacing 25% and 100% of sand by weight ...

effect of quarry dust on compressive strength concrete ...

The compressive strength of concrete from stone powder showed 14.76% higher value than that of the concrete made of normal sand (Mahzuz et al., 2011).(PDF) Stone Dust in Concrete: Effect on Compressive Strength,It is observed that the compressive strength of concrete made using 10% recycled aggregate and 60% stone dust as replacement of coarse ...

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature

(PDF) Stone Dust in Concrete: Effect on Compressive

The highest compressive strength of mortar found from stone powder which is 33.02 Mpa, shows that better mortar can be prepared by the stone powder. The compressive

Analysis of Concrete Made from Quarry Dust - IJERT

2019-7-1 · cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test at

Influence of Quarry Dust on Compressive Strength of

Objectives: In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20%, 30%, 40%, 50% replacement.Methods/Analysis: The fine aggregate is being replaced with fine aggregate and the compressive strength is determined for the concrete by testing the sample cube. The properties such as the specific gravity, fineness modulus, moisture content etc. are ...

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · (2003) reported significant increase in compressive strength, modulus of rupture and split tensile strength when 40 percent of sand is replaced by Quarry Rock Dust in concrete. Nagaraj (2000) studied that the consumption of cement content, workability, compressive strength and cost of concrete made with Quarry Rock Dust.

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature

EFFECT OF PARTIAL REPLACEMENT OF SAND WITH

2020-11-17 · of sand and quarry dust were determined in the laboratory in accordance with BS 13779 (1990). - Blocks were produced using 0, 5, 10, 15, 20, 25, 30, 35, 40, 45, and 50% partial replacement of sand with quarry dust. Compressive strength tests were carried out on the blocks after curing for 7, 14, 21 and 28 days respectively.

effect of quarry dust on compressive strength concrete ...

The compressive strength of concrete from stone powder showed 14.76% higher value than that of the concrete made of normal sand (Mahzuz et al., 2011).(PDF) Stone Dust in Concrete: Effect on Compressive Strength,It is observed that the compressive strength of concrete made using 10% recycled aggregate and 60% stone dust as replacement of coarse ...

STUDY ON PERFORMANCE OF QUARRY DUST AS FINE

2018-3-20 · that with increasing proportion of quarry dust, the strength increased to peak value (at 40%) followed by a subsequent drop in strength and a decreased workability. Key Words: Quarry dust, compressive strength, split tensile strength, reinforced-concrete. INTRODUCTION Quarry dust is the residue of particles in the size range of 0 – 4.75mm ...

An Experimental Study on Compressive Strength and ...

2021-6-4 · Strength of Concrete. Cement is being replaced with different types of waste materials to achieve the aforementioned benefits. This research paper reveals the effect of the partial replacement of cement with the Stone Quarry Dust on Compressive Strength and Splitting Tensile Strength of concrete. Cement was replaced

Research Article Study on Compressive Strength of

2019-7-30 · replaced concrete. For % quarry dust concrete workability is . and for % replacement of quarry dust concrete . compacting factor was observed. (d) e compressive strength results of quarry dust concrete (cubes) were obtained in the fourth series, where M, M, and M grades of concrete with , , and

Analysis of Concrete Made from Quarry Dust - IJERT

2019-7-1 · cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test at

Effect of compressive strength on concrete by partial ...

In the present study, it is proposed to study the effect of addition of textile sludge as cement replacement material and quarry dust as fine aggregate replacement material in the paver blocks. It is also proposed to add polypropylene fibre to increase the performance characteristics of paver blocks. In this paper control concrete pavers were made using ordinary Portland cement.

Influence of Quarry Dust on Compressive Strength of

Objectives: In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20%, 30%, 40%, 50% replacement.Methods/Analysis: The fine aggregate is being replaced with fine aggregate and the compressive strength is determined for the concrete by testing the sample cube. The properties such as the specific gravity, fineness modulus, moisture content etc. are ...

THE EFFECT OF QUARRY DUST WITH CEMENT BY

2018-11-19 · Poonam, Anoop Bishnoi, and Manju Bala. (2015). Effect of Quarry Dust as Partial Replacement of Sand in Concrete. International Journal of All Research Education and Scientific Methods 3(6):1-5. Raharjo, D., Subakti, A., and Tabvio. (2013). Mixed Concrete Optimization using Fly Ash,Silica Fume and Iron Slag on the SCC’s Compressive Strength.

Vol. 3, Special Issue 1, April 2015 A Study on Effect of ...

2015-6-2 · quarry dust for varying percentage replacement of river sand by it on the compressive strength of concrete are studied. Tests were carried on mortar cubes to study mortar compressive strength and on concrete specimens. Two basic mixes M20 and M25 were considered in the study. Tests indicate the relation between variations of compressive ...

An Experimental Study on Compressive Strength and ...

2021-6-4 · Strength of Concrete. Cement is being replaced with different types of waste materials to achieve the aforementioned benefits. This research paper reveals the effect of the partial replacement of cement with the Stone Quarry Dust on Compressive Strength and Splitting Tensile Strength of concrete. Cement was replaced

An investigation on effect of quarry dust as sand ...

Foam concrete is a type of lightweight concrete which is lighter than conventional concrete. It is non-load bearing structural element which has lower strength than conventional concrete. Foam concrete is widely used in construction field and quite popular for some application because of its light weight such as reduction of dead load, non-structural partitions and thermal insulating materials.

Analysis of Concrete Made from Quarry Dust - IJERT

2019-7-1 · cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test at

Characteristic studies on the mechanical properties of ...

2015-9-9 · Effect of quarry dust on compressive strength of concrete The 100 mm size concrete cubes were used as test specimens to determine the compressive strength. The test results of the cubes are compiled in Figures 2 to 7. 59. The compressive strength of concrete cube (100% replacement of sand with quarry dust) and natural sand were compared. The ...

Effect of compressive strength on concrete by partial ...

In the present study, it is proposed to study the effect of addition of textile sludge as cement replacement material and quarry dust as fine aggregate replacement material in the paver blocks. It is also proposed to add polypropylene fibre to increase the performance characteristics of paver blocks. In this paper control concrete pavers were made using ordinary Portland cement.

Effects of Different Fine Aggregate on Concrete Strength ...

2021-9-28 · On the other hand, concrete produced using fine aggregates obtained from Mlolongo rock sand, Naivasha sand and Mlolongo Quarry dust achieved strengths of 28.682 N/mm2 , 28.411 N/mm2 and 27.661 N/mm2 respectively falling short of the requisite compressive strength after 28 days.

Effect of quarry dust addition on the performance of ...

2012-6-2 · The performance of industrial waste incineration bottom ash in controlled low-strength material (CLSM) was investigated in this paper, as the quarry dust was added. CLSM mixtures were made from the industrial waste incineration bottom ash, quarry dust, and cement. Tests for fresh density, bleeding, compressive strength, shear strength, hydraulic conductivity, and excavatability were carried ...